|
06-17-2012, 07:49 PM
|
#1
|
Member
Join Date: Jan 2009
Posts: 79
|
2007, tourmaster/overheating
I have had my coach for 4 yrs., w/ no engine problem....left north carolina 3 wks ago, over the mtns. into tenn., over to amarrillo tex....then my troubles started, almost to las cruces, through mtns, my coach overheated, I limped into las cruces...a dealer replaced my shrayed belt......onto tuscan, 1/2 way there the coach overheated again, limped into a small shop, & they blowed the radiator...."lots of dust & debris had accumulated"....tuscan to phoenix, was "ok"....
left phoenix on rte 17 to flagstaff , an hour later....overheated again,we unhooked the car,& proceeded, but limped in....it seems that after the engine warms up, & is put under a load such as an uphill grade, she overheats....ANYONE EXPERIENCE SUCH AS THIS.
Jim
|
|
|
06-18-2012, 07:20 PM
|
#2
|
Senior Member
Join Date: Jun 2005
Posts: 1,257
|
Re: 2007, tourmaster/overheating
Do you have a side or rear radiator? If you have a rear radiator what you need to do is to wash it real good from the inside out because inside the radiator you have the CAC which gets pretty dirty and will plug up the flow of air. Spray it real good with Simple Green, let it set for a few minutes and then spray wash it. You will be surprised as to all the dirt that comes off.
If it continues to heat up, you might have a bad thermostat that is sticking. Also check to see if you are not low on anti freeze in your reservoir.
__________________
2002 Gulf Stream Scenic Cruiser
2018 Buick Envision Essence
Neway Freightliner chassis
Aventa II Blue Ox
|
|
|
06-18-2012, 08:15 PM
|
#3
|
Member
Join Date: Jan 2009
Posts: 79
|
Re: 2007, tourmaster/overheating
thks Ray, will do......freightliner thinks it is a bad sensor....hope they are right....
jim
|
|
|
06-19-2012, 04:27 PM
|
#4
|
Member
Join Date: Jun 2010
Location: St. Johns
Posts: 52
|
Re: 2007, tourmaster/overheating
Jim,
Sorry to hear you are having problems. I have not had overheating issues, but as Ray says the radiator can get real dirty on the engine side. When we had the Discovery I used to spray it regularly with Simple Green or Engine Cleaner/Degreaser and then spray real good with hose. The Tour Master seems to stay cleaner (so far).
I hope Freightliner is right about it being a sensor--they can cause false readings. My check engine light issue we chatted about in Florida ended up being the sensor in the fuel/water separator. When we got home changed both the separator and fuel filter--problem solved.
Good luck!
John
__________________
2008 Tour Master T 40A Cummins ISL 425
Toad--2013 Ford F-150 King Ranch SuperCrew 4x4
|
|
|
06-19-2012, 11:17 PM
|
#5
|
Member
Join Date: Jan 2009
Posts: 79
|
Re: 2007, tourmaster/overheating
thks John, I too hope that is the answer, freightliner thinks my radiator , coolant is ok,& when they checked the computer, no sign of over heating.....hope you two doing well, stay in touch..
Jim
|
|
|
12-10-2012, 03:42 PM
|
#6
|
Junior Member
Join Date: Aug 2010
Location: Atwater, CA
Posts: 17
|
Re: 2007, tourmaster/overheating
Did you ever find out what the problem was? I had the same thing with my 06 tourmaster. The first freightliner guy said it was nothing to be worried about as there were no codes in the system. After having the rig towed in the next time, found out there is an electric fan that went out. Freighliner fixed it under warranty and gave me a 12 month warranty on the fan. 15 months later, the fan went out again and had to be towed in. It has held since but that was my problem...
|
|
|
12-12-2012, 05:10 PM
|
#7
|
Senior Member
Join Date: Jun 2005
Posts: 1,257
|
Re: 2007, tourmaster/overheating
So what was the overheating problem Jshelley? Kind of curious as to what the problem was and you might help somebody else with that kind of problem.
__________________
2002 Gulf Stream Scenic Cruiser
2018 Buick Envision Essence
Neway Freightliner chassis
Aventa II Blue Ox
|
|
|
12-12-2012, 11:14 PM
|
#8
|
Member
Join Date: Jan 2009
Posts: 79
|
Re: 2007, tourmaster/overheating
Ray, it was the radiator, negative side, finally after 3 freightliner dealers, in 3 states, said that it was "not".....a dealer in tupelo miss., was able to get thru the fan shroud, w/ air, & 1/4" copper tubing extension......what a mess , he blew out,
PROBLEM SOLVED. but only after I had driven over 2,000 miles, by the temp guage...moral of story, clean b/ sides of radiator.
hope this helps,
Jim S
|
|
|
12-13-2012, 01:13 PM
|
#9
|
Senior Member
Join Date: Jun 2005
Posts: 1,257
|
Re: 2007, tourmaster/overheating
Jim, Glad they found the problem. I always worry when it is a heating problem. I have the rear radiator with a CAC attached right to it on the inside. I wash it at least once a year. I spray it with simple green real good and then use an electric sprayer I bought up in Oregon and I was surprised all the dirt that accumulates on those CAC and the inside of the radiator.
Thanks for the reply.
__________________
2002 Gulf Stream Scenic Cruiser
2018 Buick Envision Essence
Neway Freightliner chassis
Aventa II Blue Ox
|
|
|
02-19-2013, 03:42 PM
|
#10
|
Senior Member
Join Date: Jun 2007
Posts: 386
|
Re: 2007, tourmaster/overheating
Jim:
Sorry for the late reply, I'm just getting back in the forum.
I think there was a recall, or service advisory, that came from Cummins. You might check at a Freightliner shop about this. My Cummins ISL was one of the many involved in the recall due to
improper parts, main bearings, and I had a new engine installed. At that time, the Cummins shop told me they had to reprogram the computer to actuate the electric fans as there was some
sort of miscalculation inherit with the factory program. This was in 2008.
Just for your info, hope it helps.
__________________
Safe Travels
Rick
07 TM 40D;ISL 450 Cummins(upgraded). Very happy w/coach
Gnarly toad to scoot around.
Geocaching, hiking, fishing, National Parks, Civil War sites.
|
|
|
05-12-2013, 08:24 PM
|
#11
|
Junior Member
Join Date: May 2013
Posts: 2
|
Re: 2007, tourmaster/overheating
I travel 30,000 miles a year in my coach and overheating has been an issue. I race a car and have a 32 foot enclosed trailer on the back. In the mountains it has been overheating. What I did was clean the radiator many time to no avail. I found the clutch fan was no longer functioning when the motor got hot. Since I could not get parts for this I decided to get two 12 volt fans and a automatic start kit to run them. This start kit has a radiator sensor and is supossed to automatically fire them when the temp gets above 195. I added a remote control switch also so if they don't start I can press a button on a remote and start the fans also.
With two 16 inch fans mounted on the outside of the radiator with zip ties it really helps keep the temps in check. Total cost about $100 and we put it in two hours ( mostly wasted time trying to figure out where to mount them and wire them ). These fans are reversable in direction but luckily they pulled air instead of pushing air so we didn't have to.
|
|
|
05-12-2013, 10:40 PM
|
#12
|
Senior Member
Join Date: Jun 2005
Posts: 1,257
|
Re: 2007, tourmaster/overheating
Quote:
Originally Posted by crewchiefpro
I travel 30,000 miles a year in my coach and overheating has been an issue. I race a car and have a 32 foot enclosed trailer on the back. In the mountains it has been overheating. What I did was clean the radiator many time to no avail. I found the clutch fan was no longer functioning when the motor got hot. Since I could not get parts for this I decided to get two 12 volt fans and a automatic start kit to run them. This start kit has a radiator sensor and is supossed to automatically fire them when the temp gets above 195. I added a remote control switch also so if they don't start I can press a button on a remote and start the fans also.
With two 16 inch fans mounted on the outside of the radiator with zip ties it really helps keep the temps in check. Total cost about $100 and we put it in two hours ( mostly wasted time trying to figure out where to mount them and wire them ). These fans are reversable in direction but luckily they pulled air instead of pushing air so we didn't have to.
|
Is this a side radiator or rear radiator you have on your coach. Just wondering because you mention a clutch type fan. I have a rear radiator and the fan does not have a fan clutch, so that is why I was wondering.
__________________
2002 Gulf Stream Scenic Cruiser
2018 Buick Envision Essence
Neway Freightliner chassis
Aventa II Blue Ox
|
|
|
05-13-2013, 06:18 PM
|
#13
|
Junior Member
Join Date: May 2013
Posts: 2
|
Re: 2007, tourmaster/overheating
It is a rear radiator. 2007 Tourmaster with Mercedes engine. I thought all of them had an electric clutch fan.
|
|
|
05-18-2013, 11:22 AM
|
#14
|
Member
Join Date: May 2012
Location: Arlington
Posts: 75
|
Re: 2007, tourmaster/overheating
Quote:
Originally Posted by crewchiefpro
It is a rear radiator. 2007 Tourmaster with Mercedes engine. I thought all of them had an electric clutch fan.
|
Are you losing antifreeze at all. The fan may have an electric clutch, I'm not sure, but it is driven by a hyd. pump and that's probably where the clutch is. I'm sure you noticed a hydraulic oil resivour by the antifreeze overflow tank. I have a friend that has a cummins with the same set up. There is a hydraulic oil cooler in the line for the fan pump. This cooler sprung a leak in his. He tried to have it repaired twice to no avail. They told him they couldn't get a replacement as they were no longer made. Finally, he replaced it with a different brand (just had to figure out how to mount it) and all was well. He was leaking a small amount of antifreeze from that cooler before he had it fixed, though.
__________________
Don & Carol Niemeyer & Sandy
2006 Gulf Stream Tour Master
2011 Equinox LT1 Toad
|
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|